vin-number

Freightliner MT-45

FREIGHTLINER MT-45 2008

CERTAIN FREIGHTLINER SCHOOL BUS CHASSIS, HEAVY TRUCKS, AND THOMAS BUILT SCHOOL BUSES MANUFACTURED BETWEEN JULY 2002 AND JULY 3, 2007, EQUIPPED WITH BENDIX SR-7 SPRING BRAKE CONTROL VALVES. THE PARKER SCV BRASS 90 DEGREE SINGLE CHECK VALVES (SCV) WHICH ATTACH TO THE SUPPLY PORT OF A BENDIX SR-7 SPRING BRAKE MODULATING VALVE CAN BREAK APART. PIECES OF THE PARKER SCV CAN BECOME LODGED INSIDE THE SR-7 SPRING BRAKE MODULATING VALVE, POTENTIALLY CAUSING EITHER LEAKAGE OUT OF THE SR-7 VALVE OR PREVENTING AIR FROM PROPERLY EXHAUSTING FROM THE SR-7 VALVE. ALSO, DUE TO A MANUFACTURING DEFECT IN THE INTERNAL RUBBER CHECK VALVE INSIDE THE SR-7 SPRING BRAKE MODULATING VALVES, THE VALVES CAN BECOME DEFORMED AND NOT SEAT PROPERLY.
FREIGHTLINER MT-45 2006

CERTAIN FREIGHTLINER SCHOOL BUS CHASSIS, HEAVY TRUCKS, AND THOMAS BUILT SCHOOL BUSES MANUFACTURED BETWEEN JULY 2002 AND JULY 3, 2007, EQUIPPED WITH BENDIX SR-7 SPRING BRAKE CONTROL VALVES. THE PARKER SCV BRASS 90 DEGREE SINGLE CHECK VALVES (SCV) WHICH ATTACH TO THE SUPPLY PORT OF A BENDIX SR-7 SPRING BRAKE MODULATING VALVE CAN BREAK APART. PIECES OF THE PARKER SCV CAN BECOME LODGED INSIDE THE SR-7 SPRING BRAKE MODULATING VALVE, POTENTIALLY CAUSING EITHER LEAKAGE OUT OF THE SR-7 VALVE OR PREVENTING AIR FROM PROPERLY EXHAUSTING FROM THE SR-7 VALVE. ALSO, DUE TO A MANUFACTURING DEFECT IN THE INTERNAL RUBBER CHECK VALVE INSIDE THE SR-7 SPRING BRAKE MODULATING VALVES, THE VALVES CAN BECOME DEFORMED AND NOT SEAT PROPERLY.
FREIGHTLINER MT-45 2007

CERTAIN FREIGHTLINER SCHOOL BUS CHASSIS, HEAVY TRUCKS, AND THOMAS BUILT SCHOOL BUSES MANUFACTURED BETWEEN JULY 2002 AND JULY 3, 2007, EQUIPPED WITH BENDIX SR-7 SPRING BRAKE CONTROL VALVES. THE PARKER SCV BRASS 90 DEGREE SINGLE CHECK VALVES (SCV) WHICH ATTACH TO THE SUPPLY PORT OF A BENDIX SR-7 SPRING BRAKE MODULATING VALVE CAN BREAK APART. PIECES OF THE PARKER SCV CAN BECOME LODGED INSIDE THE SR-7 SPRING BRAKE MODULATING VALVE, POTENTIALLY CAUSING EITHER LEAKAGE OUT OF THE SR-7 VALVE OR PREVENTING AIR FROM PROPERLY EXHAUSTING FROM THE SR-7 VALVE. ALSO, DUE TO A MANUFACTURING DEFECT IN THE INTERNAL RUBBER CHECK VALVE INSIDE THE SR-7 SPRING BRAKE MODULATING VALVES, THE VALVES CAN BECOME DEFORMED AND NOT SEAT PROPERLY.
FREIGHTLINER MT-45 2005

CERTAIN FREIGHTLINER SCHOOL BUS CHASSIS, HEAVY TRUCKS, AND THOMAS BUILT SCHOOL BUSES MANUFACTURED BETWEEN JULY 2002 AND JULY 3, 2007, EQUIPPED WITH BENDIX SR-7 SPRING BRAKE CONTROL VALVES. THE PARKER SCV BRASS 90 DEGREE SINGLE CHECK VALVES (SCV) WHICH ATTACH TO THE SUPPLY PORT OF A BENDIX SR-7 SPRING BRAKE MODULATING VALVE CAN BREAK APART. PIECES OF THE PARKER SCV CAN BECOME LODGED INSIDE THE SR-7 SPRING BRAKE MODULATING VALVE, POTENTIALLY CAUSING EITHER LEAKAGE OUT OF THE SR-7 VALVE OR PREVENTING AIR FROM PROPERLY EXHAUSTING FROM THE SR-7 VALVE. ALSO, DUE TO A MANUFACTURING DEFECT IN THE INTERNAL RUBBER CHECK VALVE INSIDE THE SR-7 SPRING BRAKE MODULATING VALVES, THE VALVES CAN BECOME DEFORMED AND NOT SEAT PROPERLY.
FREIGHTLINER MT-45 2004

CERTAIN FREIGHTLINER SCHOOL BUS CHASSIS, HEAVY TRUCKS, AND THOMAS BUILT SCHOOL BUSES MANUFACTURED BETWEEN JULY 2002 AND JULY 3, 2007, EQUIPPED WITH BENDIX SR-7 SPRING BRAKE CONTROL VALVES. THE PARKER SCV BRASS 90 DEGREE SINGLE CHECK VALVES (SCV) WHICH ATTACH TO THE SUPPLY PORT OF A BENDIX SR-7 SPRING BRAKE MODULATING VALVE CAN BREAK APART. PIECES OF THE PARKER SCV CAN BECOME LODGED INSIDE THE SR-7 SPRING BRAKE MODULATING VALVE, POTENTIALLY CAUSING EITHER LEAKAGE OUT OF THE SR-7 VALVE OR PREVENTING AIR FROM PROPERLY EXHAUSTING FROM THE SR-7 VALVE. ALSO, DUE TO A MANUFACTURING DEFECT IN THE INTERNAL RUBBER CHECK VALVE INSIDE THE SR-7 SPRING BRAKE MODULATING VALVES, THE VALVES CAN BECOME DEFORMED AND NOT SEAT PROPERLY.
FREIGHTLINER MT-45 2003

CERTAIN FREIGHTLINER SCHOOL BUS CHASSIS, HEAVY TRUCKS, AND THOMAS BUILT SCHOOL BUSES MANUFACTURED BETWEEN JULY 2002 AND JULY 3, 2007, EQUIPPED WITH BENDIX SR-7 SPRING BRAKE CONTROL VALVES. THE PARKER SCV BRASS 90 DEGREE SINGLE CHECK VALVES (SCV) WHICH ATTACH TO THE SUPPLY PORT OF A BENDIX SR-7 SPRING BRAKE MODULATING VALVE CAN BREAK APART. PIECES OF THE PARKER SCV CAN BECOME LODGED INSIDE THE SR-7 SPRING BRAKE MODULATING VALVE, POTENTIALLY CAUSING EITHER LEAKAGE OUT OF THE SR-7 VALVE OR PREVENTING AIR FROM PROPERLY EXHAUSTING FROM THE SR-7 VALVE. ALSO, DUE TO A MANUFACTURING DEFECT IN THE INTERNAL RUBBER CHECK VALVE INSIDE THE SR-7 SPRING BRAKE MODULATING VALVES, THE VALVES CAN BECOME DEFORMED AND NOT SEAT PROPERLY.
FREIGHTLINER MT-45 2007

ON CERTAIN WALK-IN VANS, THE STOP LAMPS MAY BE INTERMITTENT DURING LIGHT BRAKE APPLICATIONS. THE CRUISE CONTROL MAY NOT IMMEDIATELY DEACTIVATE WHEN THE SERVICE BRAKES ARE APPLIED.
FREIGHTLINER MT-45 2005

CERTAIN 2004 AND 2005 FREIGHTLINER VAN, MOTOR HOME, SHUTTLE BUS, AND SCHOOL BUS CHASSIS MANUFACTURED BETWEEN JANUARY 2004 AND MAY 2005. ERRATIC VOLTAGE SUPPLY TO THE FUEL LIFT PUMP CAUSES PREMATURE WEAR OF THE PUMP. THIS PREMATURE WEAR COULD RESULT IN FUEL LIFT PUMP FAILURE AND IN SOME CASES MAY CAUSE AN ENGINE STALL CONDITION.
FREIGHTLINER MT-45 2004

CERTAIN VAN CHASSIS WITH SINGLE REAR TIRES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS. THE REAR TIRE RATING WAS INCORRECTLY ENTERED IN THE GAWR/GVWR CALCULATION PROGRAM ON CERTAIN SINGLE REAR TIRES. THE REAR GAWR AND GVWR WILL BE INCORRECT WHEN THE GAWR IS LIMITED BY THE TIRE CAPACITY ON CHASSIS WITH THESE TIRES.
FREIGHTLINER MT-45 2003

CERTAIN VAN CHASSIS WITH SINGLE REAR TIRES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS. THE REAR TIRE RATING WAS INCORRECTLY ENTERED IN THE GAWR/GVWR CALCULATION PROGRAM ON CERTAIN SINGLE REAR TIRES. THE REAR GAWR AND GVWR WILL BE INCORRECT WHEN THE GAWR IS LIMITED BY THE TIRE CAPACITY ON CHASSIS WITH THESE TIRES.
FREIGHTLINER MT-45 2002

CERTAIN VAN CHASSIS WITH SINGLE REAR TIRES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS. THE REAR TIRE RATING WAS INCORRECTLY ENTERED IN THE GAWR/GVWR CALCULATION PROGRAM ON CERTAIN SINGLE REAR TIRES. THE REAR GAWR AND GVWR WILL BE INCORRECT WHEN THE GAWR IS LIMITED BY THE TIRE CAPACITY ON CHASSIS WITH THESE TIRES.
FREIGHTLINER MT-45 2001

CERTAIN VAN CHASSIS WITH SINGLE REAR TIRES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS. THE REAR TIRE RATING WAS INCORRECTLY ENTERED IN THE GAWR/GVWR CALCULATION PROGRAM ON CERTAIN SINGLE REAR TIRES. THE REAR GAWR AND GVWR WILL BE INCORRECT WHEN THE GAWR IS LIMITED BY THE TIRE CAPACITY ON CHASSIS WITH THESE TIRES.
FREIGHTLINER MT-45 2000

CERTAIN VAN CHASSIS WITH SINGLE REAR TIRES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS. THE REAR TIRE RATING WAS INCORRECTLY ENTERED IN THE GAWR/GVWR CALCULATION PROGRAM ON CERTAIN SINGLE REAR TIRES. THE REAR GAWR AND GVWR WILL BE INCORRECT WHEN THE GAWR IS LIMITED BY THE TIRE CAPACITY ON CHASSIS WITH THESE TIRES.
FREIGHTLINER MT-45 2000

VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH TRW TIE ROD ENDS ON CERTAIN MERITOR AXLES. THE TIE ROD AND DRAG LINK BALL STUD ENDS CONTAIN BEARINGS THAT ARE BELOW THE SPECIFIED CASE DEPTH AND/OR HARDNESS.
FREIGHTLINER MT-45 2001

VEHICLE DESCRIPTION: STEP VANS. WATER COULD ENTER THE ELECTRICAL RELAYS RESULTING IN AN ELECTRICAL SHORT.
FREIGHTLINER MT-45 2000

VEHICLE DESCRIPTION: STEP VANS. WATER COULD ENTER THE ELECTRICAL RELAYS RESULTING IN AN ELECTRICAL SHORT.
FREIGHTLINER MT-45 2001

VEHICLE DESCRIPTION: STEP VANS. THE BACK-UP BRAKE PUMP WAS WIRED TO A 25 AMP FUSED CIRCUIT INSTEAD OF THE REQUIRED 50 AMP FUSED CIRCUIT. IF THE BACK-UP HYDRAULIC BRAKE PUMP WERE TO ENGAGE DUE TO A FAILURE IN THE PRIMARY BRAKE ASSIST SYSTEM OR THE BRAKES ARE APPLIED WITHOUT THE ENGINE RUNNING, THE FUSE COULD BLOW.
FREIGHTLINER MT-45 2000

VEHICLE DESCRIPTION: STEP VANS. THE BACK-UP BRAKE PUMP WAS WIRED TO A 25 AMP FUSED CIRCUIT INSTEAD OF THE REQUIRED 50 AMP FUSED CIRCUIT. IF THE BACK-UP HYDRAULIC BRAKE PUMP WERE TO ENGAGE DUE TO A FAILURE IN THE PRIMARY BRAKE ASSIST SYSTEM OR THE BRAKES ARE APPLIED WITHOUT THE ENGINE RUNNING, THE FUSE COULD BLOW.
FREIGHTLINER MT-45 2000

VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS, SHUTTLE BUSES, TRANSIT BUSES AND STEP VANS EQUIPPED WITH ALLISON 1000 OR 2400 SERIES TRANSMISSIONS. THESE TRANSMISSIONS CAN EXPERIENCE PARK PAWL TO REAR COVER INTERFERENCE DUE TO AN OUT OF FLATNESS CONDITION.