vin-number

NAVISTAR 3800

NAVISTAR 3800 1998

VEHICLE DESCRIPTION: SCHOOL BUS. AN AIR BRAKE LINE CONTROLLING THE REAR BRAKES MAY BE TOO CLOSE TO THE EXHAUST PIPE AND COULD RUPTURE AT ANY TIME WITHOUT WARNING.
NAVISTAR 3800 1999

VEHICLE DESCRIPTION: SCHOOL BUS. AN AIR BRAKE LINE CONTROLLING THE REAR BRAKES MAY BE TOO CLOSE TO THE EXHAUST PIPE AND COULD RUPTURE AT ANY TIME WITHOUT WARNING.
NAVISTAR 3800 1997

VEHICLE DESCRIPTION: SCHOOL BUS. AN AIR BRAKE LINE CONTROLLING THE REAR BRAKES MAY BE TOO CLOSE TO THE EXHAUST PIPE AND COULD RUPTURE AT ANY TIME WITHOUT WARNING.
NAVISTAR 3800 1998

VEHICLE DESCRIPTION: TRANSIT AND SCHOOL BUSES BUILT WITH ABS AIR BRAKE ECU AND A 100 GALLON FUEL TANK MOUNTED BETWEEN THE RAILS AND BEHIND THE REAR AXLE ON MODELS WITH A 276 WHEEL BASE. THE ABS ECU INTERFERED WITH THE CROSS MEMBER MOUNTED BEHIND THE REAR AXLE AND IN FRONT OF THE BETWEEN THE RAILS FUEL TANK. THIS CREATED A NO-BUILD SITUATION AT THE PLANT - THE PLANT WOULD EITHER ELIMINATE OR RELOCATE THE CROSS MEMBER OR MOVE THE ECU AS NEEDED.
NAVISTAR 3800 1999

VEHICLE DESCRIPTION: TRANSIT AND SCHOOL BUSES BUILT WITH ABS AIR BRAKE ECU AND A 100 GALLON FUEL TANK MOUNTED BETWEEN THE RAILS AND BEHIND THE REAR AXLE ON MODELS WITH A 276 WHEEL BASE. THE ABS ECU INTERFERED WITH THE CROSS MEMBER MOUNTED BEHIND THE REAR AXLE AND IN FRONT OF THE BETWEEN THE RAILS FUEL TANK. THIS CREATED A NO-BUILD SITUATION AT THE PLANT - THE PLANT WOULD EITHER ELIMINATE OR RELOCATE THE CROSS MEMBER OR MOVE THE ECU AS NEEDED.
NAVISTAR 3800 1999

VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS BUILT WITH REAR LEAF SPRING SUSPENSIONS (MODELS 4700 BUILT WITH REAR LEAF SUSPENSIONS AND MANUFACTURED FROM DECEMBER 9, THROUGH DECEMBER 16, 1998; MODELS 3400 AND 3800 BUILT WITH 14SBK REAR LEAF SPRING SUSPENSIONS AND BUILT APRIL 14 THROUGH MAY 10, 1999; AND MODELS 3400 AND 3800 BUILT WITH REAR LEAF SPRING SUSPENSIONS AND MANUFACTURED FROM MAY 10 THROUGH MAY 18, 1999). ON VEHICLES WHERE THE FRAME TO AXLE HOSE LENGTH WAS TOO LONG, A CHAFING CONDITION EXISTS ON SUSPENSION COMPONENTS, WHICH COULD RESULT IN HOSE RUPTURE. ON VEHICLES WHERE THE HOSES ARE TOO SHORT, A HOSE SEPARATION COULD OCCUR WITH SEVERE SUSPENSION ARTICULATION.
NAVISTAR 3800 1999

VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS, TRANSIT AND SCHOOL BUSES, EQUIPPED WITH MERITOR AIR BRAKE AUTOMATIC SLACK ADJUSTERS. SOME OF THE AUTOMATIC SLACK ADJUSTERS HAD INSUFFICIENT TORQUE APPLIED TO THE GUIDE PAWL CAP SCREW.
NAVISTAR 3800 1998

SCHOOL, TRANSIT, OR HEAVY DUTY VEHICLES EQUIPPED WITH SPICER 6,000 OR 8,000 LB. FRONT STEER AXLES. THE TIE ROD END CAN PULL OUTBOARD AND SEPARATE FROM THE TIE ROD TUBE DUE TO IMPROPER THREAD ENGAGEMENT BETWEEN THE MALE TIE ROD END AND THE FEMALE TUBE.
NAVISTAR 3800 1997

SCHOOL, TRANSIT, OR HEAVY DUTY VEHICLES EQUIPPED WITH SPICER 6,000 OR 8,000 LB. FRONT STEER AXLES. THE TIE ROD END CAN PULL OUTBOARD AND SEPARATE FROM THE TIE ROD TUBE DUE TO IMPROPER THREAD ENGAGEMENT BETWEEN THE MALE TIE ROD END AND THE FEMALE TUBE.
NAVISTAR 3800 1996

SCHOOL, TRANSIT, OR HEAVY DUTY VEHICLES EQUIPPED WITH SPICER 6,000 OR 8,000 LB. FRONT STEER AXLES. THE TIE ROD END CAN PULL OUTBOARD AND SEPARATE FROM THE TIE ROD TUBE DUE TO IMPROPER THREAD ENGAGEMENT BETWEEN THE MALE TIE ROD END AND THE FEMALE TUBE.
NAVISTAR 3800 1998

VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH T444E DIESEL ENGINES. A FUEL LEAK CAN OCCUR BECAUSE OF OVERCRIMPING OF THE HOSE END FITTINGS ON THE HOSE FROM THE REGULATOR TO THE LEFT HEAD AND THE HOSE FROM THE FUEL TRANSFER PUMP TO THE REGULATOR.
NAVISTAR 3800 1997

VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH T444E DIESEL ENGINES. A FUEL LEAK CAN OCCUR BECAUSE OF OVERCRIMPING OF THE HOSE END FITTINGS ON THE HOSE FROM THE REGULATOR TO THE LEFT HEAD AND THE HOSE FROM THE FUEL TRANSFER PUMP TO THE REGULATOR.
NAVISTAR 3800 1998

VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH A T444E DIESEL ENGINE. THE HIGH PRESSURE OILLINE FOR THE FUEL INJECTION SYSTEM THAT GOES FROM THE HIGH PRESSURE OIL PUMP TO THE RIGHT CYLINDER HEAD CAN CHAFE AGAINST THE CHARGE AIR COOLER CROSSOVER PIPE.
NAVISTAR 3800 1999

VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH A T444E DIESEL ENGINE. THE HIGH PRESSURE OILLINE FOR THE FUEL INJECTION SYSTEM THAT GOES FROM THE HIGH PRESSURE OIL PUMP TO THE RIGHT CYLINDER HEAD CAN CHAFE AGAINST THE CHARGE AIR COOLER CROSSOVER PIPE.
NAVISTAR 3800 1998

VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH A 1710 DRIVE LINE AND A 12 X 4 HYDRAULIC PARKING BRAKE. IF THE BRAKE DRUM OR TRANSMISSION YOKE ARE NOT FULLY SEATED WHEN THE EIGHT BOLTS ARE INSTALLED CONNECTING THE 3-PIECE JOINT, THE BOLTS CAN LOOSEN.
NAVISTAR 3800 1999

VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH A 1710 DRIVE LINE AND A 12 X 4 HYDRAULIC PARKING BRAKE. IF THE BRAKE DRUM OR TRANSMISSION YOKE ARE NOT FULLY SEATED WHEN THE EIGHT BOLTS ARE INSTALLED CONNECTING THE 3-PIECE JOINT, THE BOLTS CAN LOOSEN.
NAVISTAR 3800 1997

VEHICLE DESCRIPTION: BUSES AND HEAVY TRUCK CHASSIS EQUIPPED WITH T444E ENGINES. THE ACCELERATOR PEDAL ROD MATERIAL IS EXCESSIVELY BRITTLE AND CAN BREAK DURING A FULL THROTTLE APPLICATION.
NAVISTAR 3800 1997

VEHICLE DESCRIPTION: BUSES AND HEAVY TRUCK CHASSIS EQUIPPED WITH CUMMINS N-14, CATERPILLAR, AND DETROIT DIESEL ELECTRONIC ENGINES. THE ACCELERATOR PEDAL ROD MATERIAL IS EXCESSIVELY BRITTLE AND CAN BREAK DURING A FULL THROTTLE APPLICATION.
NAVISTAR 3800 1995

VEHICLE DESCRIPTION: MEDIUM AND HEAVY DUTY TRUCKS, SCHOOL AND TRANSIT BUSES BUILT WITH A BENDIX 9X3 POWER APPLY PARK BRAKE SYSTEM. THE CAM LEVER OF THE POWERED APPLY BRAKE CAN MOVE FORWARD, BECAUSE A HOLE IN THE TRANSMISSION MOUNTING BOSS WAS DRILLED TOO DEEP.
NAVISTAR 3800 1996

VEHICLE DESCRIPTION: MEDIUM AND HEAVY DUTY TRUCKS, SCHOOL AND TRANSIT BUSES BUILT WITH A BENDIX 9X3 POWER APPLY PARK BRAKE SYSTEM. THE CAM LEVER OF THE POWERED APPLY BRAKE CAN MOVE FORWARD, BECAUSE A HOLE IN THE TRANSMISSION MOUNTING BOSS WAS DRILLED TOO DEEP.
NAVISTAR 3800 1994

VEHICLE DESCRIPTION: MEDIUM AND HEAVY DUTY TRUCKS, SCHOOL AND TRANSIT BUSES BUILT WITH A BENDIX 9X3 POWER APPLY PARK BRAKE SYSTEM. THE CAM LEVER OF THE POWERED APPLY BRAKE CAN MOVE FORWARD, BECAUSE A HOLE IN THE TRANSMISSION MOUNTING BOSS WAS DRILLED TOO DEEP.
NAVISTAR 3800 1993

VEHICLE DESCRIPTION: MEDIUM AND HEAVY DUTY TRUCKS, SCHOOL AND TRANSIT BUSES BUILT WITH A BENDIX 9X3 POWER APPLY PARK BRAKE SYSTEM. THE CAM LEVER OF THE POWERED APPLY BRAKE CAN MOVE FORWARD, BECAUSE A HOLE IN THE TRANSMISSION MOUNTING BOSS WAS DRILLED TOO DEEP.
NAVISTAR 3800 1992

VEHICLE DESCRIPTION: MEDIUM AND HEAVY DUTY TRUCKS, SCHOOL AND TRANSIT BUSES BUILT WITH A BENDIX 9X3 POWER APPLY PARK BRAKE SYSTEM. THE CAM LEVER OF THE POWERED APPLY BRAKE CAN MOVE FORWARD, BECAUSE A HOLE IN THE TRANSMISSION MOUNTING BOSS WAS DRILLED TOO DEEP.
NAVISTAR 3800 1991

VEHICLE DESCRIPTION: MEDIUM AND HEAVY DUTY TRUCKS, SCHOOL AND TRANSIT BUSES BUILT WITH A BENDIX 9X3 POWER APPLY PARK BRAKE SYSTEM. THE CAM LEVER OF THE POWERED APPLY BRAKE CAN MOVE FORWARD, BECAUSE A HOLE IN THE TRANSMISSION MOUNTING BOSS WAS DRILLED TOO DEEP.